Open Journal Systems

Nonlinear controller for SEPIC with single variable to tune

Youssef El Haj, Vijay Sood, Ahmed Sheir, Ruth Milman

Abstract

This work proposes a systematic approach to design a novel integral sliding mode controller (ISMC) for a single-ended primary-inductor converter (SEPIC) with only one tunable parameter where the upper and the lower bounds are derived. The designed surface results in a minimal chattering behaviour at the output voltage as well as at the duty cycle and allows for operating the SEPIC at a fixed switching frequency. The proposed controller can withstand up to a 70% variation in the input voltage and 100% variation on the load side in addition to superior performance for a cold start. The proposed controller and the corresponding mathematical formulation were simulated in a Simulink environment and experimentally tested via a scaled prototype. The proposed controller performance is also compared to a Type-II and integral Linear-Quadratic Regulators (LQR).

Keywords

SEPIC; ISMC; systematic design; nonlinear controller

Full Text:

Untitled PDF

References

1. Kapat S, Krein PT. A Tutorial and Review Discussion of Modulation, Control and Tuning of High-Performance DC-DC Converters Based on Small-Signal and Large-Signal Approaches. IEEE Open Journal of Power Electronics. 2020; 1: 339-371. doi: 10.1109/ojpel.2020.3018311

2. Ullah Q, Busarello TDC, Brandao DI, et al. Design and Performance Evaluation of SMC-Based DC–DC Converters for Microgrid Applications. Energies. 2023; 16(10): 4212. doi: 10.3390/en16104212

3. Nicola M, Nicola CI, Selișteanu D. Improvement of the Control of a Grid Connected Photovoltaic System Based on Synergetic and Sliding Mode Controllers Using a Reinforcement Learning Deep Deterministic Policy Gradient Agent. Energies. 2022; 15(7): 2392. doi: 10.3390/en15072392

4. Erickson RW, Maksimović D. Fundamentals of Power Electronics. Springer US; 2001. doi: 10.1007/b100747

5. Mohan N. Advanced Electric Drives: Analysis, Control and Modeling Using Simulink by Ned Mohan. Mnpere, 1707.

6. Aroudi AE, Mandal K, Al-Numay MS, et al. Piecewise Quadratic Slope Compensation Technique for DC-DC Switching Converters. IEEE Transactions on Circuits and Systems I: Regular Papers. 2020; 67(12): 5574-5585. doi: 10.1109/tcsi.2020.2993793

7. Deisch C. Simple switching control method changes power converter into a current source. 1978 IEEE Power Electronics Specialists Conference. Published online June 1978. doi: 10.1109/pesc.1978.7072368

8. Liu YF, Meyer E, Xiaodong Liu. Recent Developments in Digital Control Strategies for DC/DC Switching Power Converters. IEEE Transactions on Power Electronics. 2009; 24(11): 2567-2577. doi: 10.1109/tpel.2009.2030809

9. Khalil H. Nonlinear Systems, 3rd ed. Upper Saddle River, N.J: Pearson, 2001.

10. Tan SC, Lai YM, Tse CK. General Design Issues of Sliding-Mode Controllers in DC–DC Converters. IEEE Transactions on Industrial Electronics. 2008; 55(3): 1160-1174. doi: 10.1109/tie.2007.909058

11. Wang J, Rong J, Yu L. Dynamic prescribed performance sliding mode control for DC–DC buck converter system with mismatched time-varying disturbances. ISA Transactions. 2022; 129: 546-557. doi: 10.1016/j.isatra.2022.02.019

12. Buckner GD. Intelligent bounds on modeling uncertainty: applications to sliding mode control. IEEE Transactions on Systems, Man and Cybernetics, Part C (Applications and Reviews). 2002; 32(2): 113-124. doi: 10.1109/tsmcc.2002.801350

13. Pandey SK, Veeranna K, Patil SL, et al. Uncertainty Estimator based Sliding Mode Control Schemes for Multimode Noninverting Buck-Boost DC-DC Converter. IFAC-PapersOnLine. 2020; 53(1): 555-560. doi: 10.1016/j.ifacol.2020.06.093

14. Zhang L, Wang Z, Li S, et al. Universal finite-time observer based second-order sliding mode control for DC-DC buck converters with only output voltage measurement. Journal of the Franklin Institute. 2020; 357(16): 11863-11879. doi: 10.1016/j.jfranklin.2019.11.057

15. Hamed SB, Hamed MB, Sbita L. Robust Voltage Control of a Buck DC-DC Converter: A Sliding Mode Approach. Energies. 2022; 15(17): 6128. doi: 10.3390/en15176128

16. Chincholkar SH, Jiang W, Chan CY. A Modified Hysteresis-Modulation-Based Sliding Mode Control for Improved Performance in Hybrid DC–DC Boost Converter. IEEE Transactions on Circuits and Systems II: Express Briefs. 2018; 65(11): 1683-1687. doi: 10.1109/tcsii.2017.2784549

17. Wang Y, Duan G, Yu J, et al. Harmonic Analysis of Sliding-Mode-Controlled Buck Converters Imposed by Unmodeled Dynamics of Hall Sensor. Energies. 2023; 16(17): 6124. doi: 10.3390/en16176124

18. González I, Sánchez-Squella A, Langarica-Cordoba D, et al. A PI + Sliding-Mode Controller Based on the Discontinuous Conduction Mode for a Unidirectional Buck–Boost Converter with Electric Vehicle Applications. Energies. 2021; 14(20): 6785. doi: 10.3390/en14206785

19. Pandey SK, Patil SL, Phadke SB. Regulation of Nonminimum Phase DC–DC Converters Using Integral Sliding Mode Control Combined with a Disturbance Observer. IEEE Transactions on Circuits and Systems II: Express Briefs. 2018; 65(11): 1649-1653. doi: 10.1109/tcsii.2017.2759908

20. Ghosh SK, Roy TK, Pramanik MdAH, et al. Design of Nonlinear Backstepping Double-Integral Sliding Mode Controllers to Stabilize the DC-Bus Voltage for DC–DC Converters Feeding CPLs. Energies. 2021; 14(20): 6753. doi: 10.3390/en14206753

21. Das S, Salim Qureshi M, Swarnkar P. Design of integral sliding mode control for DC-DC converters. Materials Today: Proceedings. 2018; 5(2): 4290-4298. doi: 10.1016/j.matpr.2017.11.694

22. Bensaada M, Boudghene Stambouli A. A practical design sliding mode controller for DC–DC converter based on control parameters optimization using assigned poles associate to genetic algorithm. International Journal of Electrical Power & Energy Systems. 2013; 53: 761-773. doi: 10.1016/j.ijepes.2013.05.043

23. Komurcugil H. Adaptive terminal sliding-mode control strategy for DC–DC buck converters. ISA Transactions. 2012; 51(6): 673-681. doi: 10.1016/j.isatra.2012.07.005

24. Mahdavi J, Nasiri MR, Agah A, et al. Application of Neural Networks and State-Space Averaging to DC/DC PWM Converters in Sliding-Mode Operation. IEEE/ASME Transactions on Mechatronics. 2005; 10(1): 60-67. doi: 10.1109/tmech.2004.842227

25. Sarkar TT, Mahanta C. Estimation Based Sliding Mode Control of DC-DC Boost Converters. IFAC-PapersOnLine. 2022; 55(1): 467-472. doi: 10.1016/j.ifacol.2022.04.077

26. Gireesh G, Seema PN. High frequency SEPIC Converter with PWM Integral Sliding Mode Control. 2015 International Conference on Technological Advancements in Power and Energy (TAP Energy). Published online June 2015. doi: 10.1109/tapenergy.2015.7229651

27. Salazar-Duque JE, Ortiz-Rivera EI, Gonzalez-Llorente J. Analysis and non-linear control of SEPIC dc-dc converter in photovoltaic systems. 2015 IEEE Workshop on Power Electronics and Power Quality Applications (PEPQA). Published online June 2015. doi: 10.1109/pepqa.2015.7168243

28. Kavitha A, Indira G, Uma G. Analysis and Control of Chaos in SEPIC DC-DC Converter Using Sliding Mode Control. 2008 IEEE Industry Applications Society Annual Meeting. Published online October 2008. doi: 10.1109/08ias.2008.289

29. Ablay G. Robust tracking controller for SEPIC drivers. Electronics Letters. 2016; 52(24): 2007-2009. doi: 10.1049/el.2016.3427

30. Li N, Lin-Shi X, Lefranc P, et al. Universal DC-DC converter using SEPIC. In: Proceedings of the 2011 14th European Conference on Power Electronics and Applications, Aug. 2011, pp. 1–10.

31. Komurcugil H, Biricik S, Guler N. Indirect Sliding Mode Control for DC–DC SEPIC Converters. IEEE Transactions on Industrial Informatics. 2020; 16(6): 4099-4108. doi: 10.1109/tii.2019.2960067

32. Jaafar A, Godoy E, Lefranc P, et al. Nonlinear sliding mode observer and control of high order DC-DC converters. IECON 2010—36th Annual Conference on IEEE Industrial Electronics Society. Published online November 2010. doi: 10.1109/iecon.2010.5675208

33. Basso CP. Designing control loops for linear and switching power supplies: A tutorial guide. Boston: Artech House, 2012.


DOI: https://doi.org/10.59400/esc.v2i1.426
(44 Abstract Views, 0 Untitled Downloads21 PDF Downloads)

Refbacks

  • There are currently no refbacks.


Copyright (c) 2024 Youssef El Haj, Vijay Sood, Ahmed Sheir, Ruth Milman

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.


This site is licensed under a Creative Commons Attribution 4.0 International License.